ensemble systems Kothrud, Pune, Maharashtra

A very useful device to heat the water for domestic, industries hotel, hostels, hospitals. Now a days it is very much popular in India where good solar energy is available. Till today we have installed number of solar water heaters for builders , hotels, hospitals, individual bungalows , industries. Solar systems could coated after understanding site conditions however small capacity of systems normally used for residential purpose, are available ex stock.Operating principle, - There are two types of solar water heating systems , one is thermo-siphon the other one is forced type systems  Thermo-siphon - in which with the use of solar energy , water gets heated in solar collectors results, density of water reduces and became lighted than cold water. Cold water being heavier than hot water , it pushed hot water into the tank , in this way hot water gets circulated by thermo siphoning ,,The storage tank being insulated , water remains hot till next day . In this system maximum temperature of 70 degree could be achieved   Forced Systems water gets heated in solar collectors with the use of solar energy , In this type of systems water is circulated through the panels using electrical pump. This type of systems normally used where the system capacity is large ( more than 5000lit/ day )

On this scenario producing better quality agricultural products and post harvesting technologies also very important. But unfortunately in India up to 25 % to 30 % of the agricultural produce get wasted because of heavy production or some times farmers suffer heavy losses because of fall in selling rates. For example coriander rate per bunch in season is very cheap around rs 2-3 per bunch , and in off season rates goes as high as rs 10 to 12 Rupees per bunch. But if this losses could be prevented by better and cost effective post harvesting process. We are very well aware of cold storage, where the agricultural produce is being stores in lower temperature and being used as and when required. “solar dry storage” is our unique concept were agricultural produce could be dehydrated using solar drying system and then preserved in vacuumed packed packaging , so that it could be used when it is required , comparing to cold storage running cost of solar dry storage system could be very low because dehydrated agricultural produce could be stored in normal temperature . As in our country there is large amount of solar energy available this could be used to dehydrate the agricultural produce. This dry storage cold run on back up system of any other fuel like LPG or even waste from farms. With the time eating habits of people are changing ready to eat , ready to cook food products are increasing in demands. Use of powders is increasing , many snacks industries need dehydrated powders for their products. This type of project could be installed in any interior village because it is difficult to carry their agricultural produce in big cities , after drying the volume and the weight of material reduces and it results into reducing in transport cost. This project could be very useful to avoid the wastage of fruits and vegetables. This “Solar dry storage “ could be connected to market place where they could display their stock. So that merchants cold buy dehydrated fruits and vegetables as per their need.

The Solar Home Lighting System comprises of, LED’s, Low Maintenance Tubular Lead Acid Battery, SPV Modules, SPV Charge Controller, and Inter-connecting Cables of approximately 15 meters length.  LED lighting system We provide most efficient LED based solar lighting systems , Comparing to the other lighting systems ( Normal tube light and CFLs) LED lighting systems are most efficient systems. LED lighting systems are 5 times and 3 times efficient than normal tube lighting systems and CFLs respectively. The demand of LED and solar products is increasing all over the world. We offer a variety of LED and Solar products, best both in terms of quality and design excellence. Our products are made from the best raw materials and known for their functional value BATTERYBatteries are essential component in a SPV system, where energy has to be stored during the day and used in the night.  A typical application being Solar Home Lighting System.  The type of Battery used in Solar Home Lighting System is Low Maintenance Tubular, Lead-Acid Battery.  Being Low Maintenance, it gives long trouble-free Service, requiring attention typically once in 3 to 6 months.SPV CHARGE CONTROLLERThe functions of the “SPV CHARGE CONTROLLER” is to control charging the battery from the solar modules and also to control the load connection to the battery. The solar modules charge the battery through the “SPV CHARGE CONTROLLER”.  When the battery reaches its full state of charge, the “SPV CHARGE CONTROLLER” disconnects the solar modules.  Thereby, prevents over charging of the battery and thus minimizes the loss of electrolyte.  The solar modules are again reconnected when the battery voltage is low.  Disconnection and reconnection of the solar module is done automatically by the “SPV CHARGE CONTROLLER’. PV modules Home lighting System are powered by solar energy using solar cells that convert solar energy (sunlight) directly to electricity. The electricity is stored in batteries and used for the purpose of lighting whenever required. These systems are useful in non-electrified rural areas and as reliable emergency lighting system for important domestic, commercial and industrial applications. The Solar Home Lighting system is a fixed installation designed for domestic application. The solar module is installed in the open on roof/terrace - exposed to sunlight and the charge controller and battery are kept inside a protected place in the house. The solar module requires periodic dusting for effective performance.

Broadly the systems have two parts one is the Electronic Unit and the other is the fence. Electronic unit consists of a Solar Photo Voltaic Module, Energizer, Alarm (FVA), Battery and Charge controller with the solar Photovoltaic Module electrical energy is being generated and which charges the battery through charge controller. The energizer through the charge controller takes 12V supply as input and energizes the same into 8000 to 9900 volt pulses. These pulses will travel through the fencing wires at regular interval of around 1 pulse per 1.2 second with the duration of each pulse about 3 mille seconds. Maximum length that can be covered using a control unit is 12000 running meters. Gate can also be electrified without causing any inconvenience to the users. It denies entry by climbing the gate. Fencing for farms - This solar fencing could be used to protect crops from domestic and wild animals like Wild Boar, Monkeys, Cows etc. Fence design shall be exclusively to meet the targeted animal(s) installed around the crop using existing posts. The poles could be made up of be Wood, RCC solid pipe, etc duly grouted on the ground to carry fence strands along the perimeter.   Fencing for farm house , bungalows - This type of fence is installed either on the wall or on ground level. Control unit shall consist of single channel Energizer Fence Voltage Alarm, Solar Photovoltaic Module, Battery, Metal enclosure and Neon tester. Advanced version of Security fence can be considered as High Security Fence. It is designed to protect premises from all types of intrusions and make the perimeter a foolproof system. For more information please contact.

Solar dry storage Since ages, people have been using sun for drying different types of food products. That way, the food can be conserved and therefore consumed or sold in the market. However, drying in the open sun may not be hygienic, it takes a long time to dry and rain may slow down the drying process. Due to time constraints, the food is not always fully dried, sometimes resulting in re-growth of bacteria and fungus. In order to obtain hygienic food that can be stored for a longer time, the solar drying technology could be used. The traditional method of drying is to spread the food openly in the sun. In this drying method, the food is often contaminated, damaged or lost by dust and animals A solar dryer is a closed unit, resulting in several advantages: Solar thermal power is trapped, resulting in a higher temperature around the food items. This decreases the drying time & nutritional values of are conserved In rainy periods, rain will not slow down the drying process. There are two types of solar dryers ,direct exposed to sun rays and indirect drying. In Solar Dryer sunlight used to evaporate the moisture from food items. In typical solar dryer glass or plastic lid allows the sunlight into the dryer, the black painted tray absorbs sunlight effectively and converts it into heat, this results the temperature of the food items increases & moisture get evaporated .inner atmosphere of the dryer becomes damp & this damp air escapes through the upper outlets same time fresh air enters through the lower inlets. the moisture content of food is decreased more quickly than in open air. Advantages of solar DryerIt is time saving drying process Food is protected from dust, insects, flies, birds and animals, It require less attention better quality and nutritious dry foods, very simple to operate, no energy is required We can design, manufacture & install solar dryers for different type of food material.

On this scenario producing better quality agricultural products and post harvesting technologies also very important. But unfortunately in India up to 25 % to 30 % of the agricultural produce get wasted because of heavy production or some times farmers suffer heavy losses because of fall in selling rates. For example coriander rate per bunch in season is very cheap around rs 2-3 per bunch , and in off season rates goes as high as rs 10 to 12 Rupees per bunch. But if this losses could be prevented by better and cost effective post harvesting process. We are very well aware of cold storage, where the agricultural produce is being stores in lower temperature and being used as and when required. “solar dry storage” is our unique concept were agricultural produce could be dehydrated using solar drying system and then preserved in vacuumed packed packaging , so that it could be used when it is required , comparing to cold storage running cost of solar dry storage system could be very low because dehydrated agricultural produce could be stored in normal temperature . As in our country there is large amount of solar energy available this could be used to dehydrate the agricultural produce. This dry storage cold run on back up system of any other fuel like LPG or even waste from farms. With the time eating habits of people are changing ready to eat , ready to cook food products are increasing in demands. Use of powders is increasing , many snacks industries need dehydrated powders for their products. This type of project could be installed in any interior village because it is difficult to carry their agricultural produce in big cities , after drying the volume and the weight of material reduces and it results into reducing in transport cost. This project could be very useful to avoid the wastage of fruits and vegetables. This “Solar dry storage “ could be connected to market place where they could display their stock. So that merchants cold buy dehydrated fruits and vegetables as per their need.

In today’s economy and the big gap between the demand and supply of energy it is necessary for all of us to look at different sources of energy. Solar Energy is a nature’s greatest gift to mankind, and that is where we play a role in utilizing the potential of this renewable energy for the last eighteen years. We have earned a impeccable repute in our domain knowledge of Solar systems. There is a lot of scope in saving energy , time an labor hours in agro , Ayurvedic pharmacy , food processing industries by modifying existing machines , designing custom made machines And we have innovated the same.

Small scale windmills are very cost effective power solution comparing to solar photovoltaic systems . With speed of 8 to 10 Km/hours it cold generate 300 – 400 watt peak power. Which is very much useful for lighting system. This machine is light weight and could be installed on roof top. Wind power could be available 24 hours a day and 12mounths in year. With proper charge controller and battery banks it could a very good power source.