AIR Preheaters Dealers in Coimbatore (6 products available)

Material : Stainless Steel

Power : 1-3kw

Capacity : 4000 kg/hr

Primary Exchanger Material : Steel

Flow Rate (L/min) : 140 L/min

Temperature : 300 degree

An air preheater (APH) is general term to describe any device designed to heat air before another process (for example, combustion in a boiler) with the primary objective of increasing the thermal efficiency of the process. They may be used alone or to replace a recuperative heat system or to replace a steam coil. In particular, this article describes the combustion air preheaters used in large boilers found in thermal power stations producing electric power from e.g. fossil fuels, biomasses or waste. The purpose of the air preheater is to recover the heat from the boiler flue gas which increases the thermal efficiency of the boiler by reducing the useful heat lost in the flue gas. As a consequence, the flue gases are also sent to the flue gas stack at a lower temperature, allowing simplified design of the ducting and the flue gas stack. It also allows control over the temperature of gases leaving the stack. Air pre-heater transfer heat from flue gas to air by means of a rotary matrix in which heat is absorbed by the heating elements passing through the hot gas stream & transferred to the combustion air stream.

The Flue Gas Air Pre Heater station air is generally totally dry air is required for the instrumentation, so the air used to drive the rotor is injected with oil to lubricate the air motor. Flue Gas Air Pre Heater and circumferential seal plates are also provided to avoid leakages of gases or air between the sectors or between the duct and the casing while in rotation. The Flue Gas Air Pre Heaters are in the sector housings provided on the rotor and are renewable. Flue Gas Air Pre Heater are provided for viewing the preheater's internal operation under all operating conditions. Flue Gas Air Pre Heater is connected for emptying along with the main dust hoppers of the dust collectors.

Jc equipments are the leading manufacturers of flue gas air pre heater in india. The two types of flue gas air pre heaters are given below and the combustion gas transfers its own heat to the water wall, the superheaters, the reheater and the economizer, then leaves the boiler to the flue gas ducts. The flue gas goes to the stack through the ah and is exhausted to the atmosphere.

We are offering ladle preheater. Ladle used for heating refractory linings of various sizes of lip-pouring and bottom- pouring ladles. It has horizontal steel frame pivoted at its centre.

Flue Gas Air Preheater, Mist Eliminators, Metal Tubes, Marine Heat Exchanger